Bought a 99 HDI 90 but Air con faulty.

Oct 05, 2003 2 Replies
M

Bought a 99 HDI 90 but Air con faulty.



Haynes manual not much use as it doesn't tell me where the compressor or evaporator are actually located, only gives a CAD drawing of it, no photo's that I can see.



So problem is: Air con light lights up on dash but no air con. There is no 'click' of a relay to be heard either under the bonnet.



I do notice that there are what looks like stainless steel pipes to the right of the radiator going into the right side of the radiator(or into thr right side in front of the radiator). It looks like a little clip is hanging 6 inches away from a joint where two pieces of this steel pipe connect together.



Could this be a possible leak?



Did anyone find out where a condensor could be purchased if it is that that is leaking?



Someone tell me where in the engine the compressor is so I can voltage test it?


Thanks.


Vote
Twitter Facebook LinkedIn
C

Micheal, If it's the 406 HDI 90, the condensor is behind the radiator, or at the front of the car. Mine had a leak and I purchased one from a place on the net called vehicool at about £123 inc VAT and Del. The garage told me it would be £330. so I did it myself and got it gassed for £50.

The compressor is connected to the fan belt i think on the bottom lefhand side of the engine, looks a bit like an alternator. When you press the aircon. button the click is from the clutch on the compressor kicking in. but it will only do so if you have enough gas in.

What I did was to uncouple the wires from the compressor and put 12v on them, this then activated the clutch, so I new that was working.

Hope this helps abit

Richard

Vote
Twitter Facebook LinkedIn
A

Hej,

Please be aware, that an outside temperature below approximately freezing will also cause the air con not to activate because the evaporator temperature is just above freezing.

I actually sent my '99 406 to Service because of this. It was not a fault but normal operation.

Regards

Allan

"Cabin" skrev i en meddelelse news:bls3av$gki$ snipped-for-privacy@newsg2.svr.pol.co.uk...

Vote
Twitter Facebook LinkedIn

Join the Discussion

Have something to add? Share your thoughts — no account required.

Didn't find your answer?

Ask the community — no account required