Ford F150 owner's manual: Maintenance and Specifications (continued)

Maintenance and Specifications

Never spin the tires in excess of the 35 mph (55 km/h) point indicated on the speedometer.

Highway hazards

No matter how carefully you drive there's always the possibility that you may eventually have a flat tire on the highway. Drive slowly to the closest safe area out of traffic. This may further damage the flat tire, but your safety is more important.

If you feel a sudden vibration or ride disturbance while driving, or you suspect your tire or vehicle has been damaged, immediately reduce your speed. Drive with caution until you can safely pull off the road. Stop and inspect the tires for damage. If a tire is under-inflated or damaged, deflate it, remove wheel and replace it with your spare tire and wheel. If you cannot detect a cause, have the vehicle towed to the nearest repair facility or tire dealer to have the vehicle inspected.

SNOW TIRES AND CHAINS

Snow tires must be the same size and grade as the tires you currently have on your vehicle.

The tires on your vehicle have all weather treads to provide traction in rain and snow. However, in some climates, you may need to use snow tires and chains. If you need to use chains, it is recommended that steel wheels (of the same size and specifications) be used, as chains may chip aluminum wheels.

Follow these guidelines when using snow tires and chains:

• Use only SAE Class S chains.
• Install chains securely, verifying that the chains do not touch any wiring, brake lines or fuel lines.
• Drive cautiously. If you hear the chains rub or bang against your vehicle, stop and re-tighten the chains. If this does not work, remove the chains to prevent damage to your vehicle.
• If possible, avoid fully loading your vehicle.
• Remove the tire chains when they are no longer needed. Do not use tire chains on dry roads.
• The suspension insulation and bumpers will help prevent vehicle damage. Do not remove these components from your vehicle when using snow tires and chains.

274

Maintenance and Specifications

MOTORCRAFT PART NUMBERS

$^{1}$The PCV valve is a critical emission component. It is one of the items listed in the Scheduled Maintenance Guide and is essential to the life and performance of your vehicle and to its emissions system.

For PCV valve replacement, see your dealer or a qualified service technician. Refer to the Scheduled Maintenance Guide for the appropriate intervals for changing the PCV valve.

Replace the PCV valve with one that meets Ford material and design specifications for your vehicle, such as a Motorcraft or equivalent replacement part. The customer warranty may be void for any damage to the emissions system if such a PCV valve is not used.

$^{2}$For spark plug replacement, see your dealer or a qualified service technician. Refer to the Scheduled Maintenance Guide for the appropriate intervals for changing the spark plugs.

Replace the spark plugs with ones that meet Ford material and design specifications for your vehicle, such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used.

Refer to Vehicle Emissions Control Information (VECI) decal for spark plug gap information.

$^{3}$The 4.6L engine is produced with two different oil filters depending on which engine plant is was produced in. Please refer to the label on the engine, on the valve/cam cover, to determine which replacement oil filter to use for your application. If the label shows “REP” it uses oil filter number FL-820-S. If the label shows “Ford Windsor” it uses oil filter number FL-400-S. The correct oil filter must be used as previously described.

275

Maintenance and Specifications

REFILL CAPACITIES

276

Maintenance and Specifications

277

Maintenance and Specifications

¹Add the coolant type originally equipped in your vehicle.

²Service refill capacity is determined by filling the transfer case to the bottom of the filler hole with the vehicle on a level surface.

³Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your Scheduled Maintenance Guide to determine the correct service interval.

Some transmission fluids may be labeled as dual usage, such as MERCON® and MERCON® V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON® type

278

Maintenance and Specifications

fluid. However, these dual usage fluids may be used in transmissions that require the MERCON® V type fluid.

MERCON® and MERCON® V type fluids are not interchangeable. DO NOT mix MERCON® and MERCON® V. Use of a transmission fluid that indicates dual usage (MERCON® and MERCON® V) in an automatic transmission application requiring MERCON® may cause transmission damage. Use of any fluid other than the recommended fluid may cause transmission damage.

$^{4}$Approximate dry fill capacity including transmission fluid cooling system, actual refill capacities will vary based on vehicle application and transmission fluid cooling system (i.e. coolers size, cooling lines. auxiliary cooler capacities). The amount of transmission fluid and fluid level should be set by the indication on the dipstick's normal operating range.

$^{5}$Your vehicle's rear axle is filled with a synthetic rear axle lubricant and is considered lubricated for life. These lubricants do not need to be checked or changed unless a leak is suspected, service is required or the axle assembly has been submerged in water. The axle lubricant should be changed any time the rear axle has been submerged in water.

$^{6}$Service refill capacity is determined by filling the axle to 1/4-9/16 inch (6-14 mm) below the bottom of the filler hole with the vehicle on a level surface.

Add 4 oz. (118 ml) of FEHP Friction Modifier, XL-7 or equivalent, for complete fill of 8.8 inch and 9.75 inch Traction-Lok axles.

$^{7}$Service refill capacity is determined by filling the axle to the bottom of the filler hole with the vehicle on a level surface.

For 10.25 inch Traction-Lok axles, use 6.5 pints (3.1L) of Motorcraft SAE 75W-90 Fuel Efficient High Performance Synthetic Rear Axle Lubricant and 4 oz. (118 ml) of FEHP Friction Modifier XL-7 or equivalent.

$^{8}$Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the requirements of Ford specification WSS-M2C153-H and the API Certification mark.

279

Maintenance and Specifications

LUBRICANT SPECIFICATIONS

280

Maintenance and Specifications

¹Add 4 oz (118 ml) of FEHP Friction Modifier XL-7 or equivalent for complete refill of Traction-Lok axles.

²Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your Scheduled Maintenance Guide to determine the correct service interval.

281

Maintenance and Specifications

Some transmission fluids may be labeled as dual usage, such as MERCON® and MERCON® V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON® type fluid. However, these dual usage fluids may be used in transmissions that require the MERCON® V type fluid.

MERCON® and MERCON® V type fluids are not interchangeable. DO NOT mix MERCON® and MERCON® V. Use of a transmission fluid that indicates dual usage (MERCON® and MERCON® V) in an automatic transmission application requiring MERCON® may cause transmission damage. Use of any fluid other than the recommended fluid may cause transmission damage.

ENGINE DATA

$^1$The 5.4L 3V spark plug gap CANNOT be adjusted.

282

Maintenance and Specifications

VEHICLE DIMENSIONS

Regular Cab

283

Maintenance and Specifications

SuperCab

284

Maintenance and Specifications

285

Maintenance and Specifications

Super Crew

286

Maintenance and Specifications

IDENTIFYING YOUR VEHICLE

Certification label

The National Highway Traffic Safety Administration Regulations require that a Certification label be affixed to a vehicle and prescribe where the Certification label may be located. The Certification label is located on the structure by the trailing edge of the driver's door or the edge of the driver's door.

MFD. BY FORD MOTOR CO. IN U.S.A. DATE: XX/XX FRONT GAWR: XXXXL XXXXKG WITH XXXX/XXXXXXX TIRES XXXX.XX RIMS AT XXX kPa/XX PSI COLD GVWR: XXXXXLB/ XXXXXKG REAR GAWR: XXXXLB XXXXKG WITH XXXX/XXXXXXX TIRES XXXX.XX RIMS AT XXX kPa/XX PSI COLD THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL MOTOR VEHICLE SAFETY AND THEFT PREVENTION STANDARDS IN EFFECT ON THE DATE OF MANUFACTURE SHOWN ABOVE. VIN: XXXXXXXXXXXXXXXXX TYPE: XXX XXXXX XXXXX EXT PNT: XX RC: XX DSO: WB BRK INT TR TP/PS R AXLE TR SPR XXXXX XXX X XX X XX X XX XXX XXXXXXXXXXXXX UTC 72USA 1520472 AA

287

Maintenance and Specifications

Vehicle identification number (VIN)

The vehicle identification number is attached to a metal tag and is located on the driver side instrument panel. (Please note that in the graphic XXXX is representative of your vehicle identification number.)

1. World manufacturer identifier
2. Brake type and gross vehicle weight rating (GVWR)
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number

E ngine number

The engine number (the last eight numbers of the vehicle identification number) is stamped on the engine block and transmission.

288

Maintenance and Specifications

Transmission/Transaxle code designations

You can find a transmission/transaxle code on the vehicle certification label. The following table tells you which transmission or transaxle each code represents.

Truck application:

Maintenance and Specifications

Passenger car application:

290

Accessories

GENUINE FORD ACCESSORIES FOR YOUR VEHICLE

A wide selection of Genuine Ford Accessories are available for your vehicle through your local authorized Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle. In addition, each accessory is made from high quality materials and meets or exceeds Ford's rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly dealer-installed Genuine Ford Accessory found to be defective in factory-supplied materials or workmanship during the warranty period, as well as any component damaged by the defective accessory. The accessory will be warranted for whichever provides you the greatest benefit:

• 12 months or 12,000 miles (20,000 km) (whichever occurs first), or
• the remainder of your new vehicle limited warranty.

This means that Genuine Ford Accessories purchased along with your new vehicle and installed by the dealer are covered for the full length of your New Vehicle's Limited Warranty — 3 years or 36,000 miles (60,000 km) (whichever occurs first). Contact your dealer for details and a copy of the warranty.

Not all accessories are available for all models.

The following is a list of several Genuine Ford Accessory products for your vehicle. Not all accessories are available for all models. For a complete listing of the accessories that are available for your vehicle, please contact your dealer or visit our online store at: www.fordaccessoriesstore.com.

Exterior style Bug shields Deflectors Exterior trim Fender flares Front end covers Grille inserts Headlamps, taillamps, fog lights and Daytime Running Lamps (DRLs) Running boards Sliding rear windows - manual and power

291

Accessories

Splash guards Step bars Tonneau covers Truck caps Wheels

I nterior style

Cell phone holders Consoles Electrochromatic compass/temperature interior mirrors Floor mats Interior trim kits Leather wrapped steering wheels Scuff plates Speed control

Lifestyle

Bedliners and bedmats Bed tents Bike racks Cargo organization and management Diamond plate accessories Engine block heaters and blankets Rear seat entertainment systems Toolboxes Towing mirrors TracRac and accessories Trailer hitches, wiring harnesses and accessories

Peace of mind

Airbag anti-theft locks First aid and highway safety kits Full vehicle covers

292

Accessories

Locking gas cap Navigation systems Remote start Vehicle security systems

For maximum vehicle performance, keep the following information in mind when adding accessories or equipment to your vehicle:

• When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR or GAWR as indicated on the Safety Compliance Certification label). Consult your dealer for specific weight information.
• The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the use of mobile communications systems — such as two-way radios, telephones and theft alarms - that are equipped with radio transmitters. Any such equipment installed in your vehicle should comply with FCC or CRTC regulations and should be installed only by a qualified service technician.
• Mobile communications systems may harm the operation of your vehicle, particularly if they are not properly designed for automotive use.
• Electrical or electronic accessories or components that are non-Genuine Ford Accessories added to the vehicle by the dealer or the owner may adversely affect battery performance and durability.

293

Index

A

• Accessory delay ........ 60 Air bag supplemental
• restraint system ........ 121–122
• and child safety seats ........ 124
• description ........ 122
• disposal ........ 126
• driver air bag ........ 122, 125
• indicator light ........ 126
• operation ........ 122, 125
• passenger air bag ........ 122, 125 passenger deactivation
• switch ........ 130
• Air cleaner filter ........ 259–260, 275
• Air conditioning ........ 35, 38
• Ambulance packages ........ 7 Antifreeze
• (see Engine coolant) ........ 239 Anti-lock brake system
• (see Brakes) ........ 154
• Armrests ........ 100 Audio system
• (see Radio) ........ 18, 20, 23, 26 Automatic transmission driving an automatic
• overdrive ........ 159
• fluid, adding ........ 256
• fluid, checking ........ 256
• fluid, refill capacities ........ 276
• fluid, specification ........ 282 Axle lubricant specifications ..280, 282
• refill capacities ........ 276
• traction lok ........ 156

B

• Battery ........ 237

• acid, treating emergencies ........ 237

• jumping a disabled battery ........ 209

• maintenance-free ........ 237 replacement, specifications ...275

• servicing ........ 237

• Bed extender ........ 82

• Brakes ........ 154

• anti-lock ........ 154 anti-lock brake system

• (ABS) warning light ........ 154 fluid, checking and adding ...256

• fluid, refill capacities ........ 276

• fluid, specifications ........ 280, 282 lubricant specifications ..280, 282

• parking ........ 155

• shift interlock ........ 156–157

• Bulbs ........ 48

C

• Calculating load ........ 179 Capacities for refilling fluids ..276
• Cell phone use ........ 58
• Certification Label ........ 287
• Changing a tire ........ 203
• Child safety restraints ........ 135
• child safety belts ........ 135
• Child safety seats ........ 138 attaching with tether straps ..142
• in front seat ........ 139
• in rear seat ........ 139, 142 Cleaning your vehicle
• engine compartment ........ 225
• instrument panel ........ 227
• interior ........ 228
• interior trim ........ 227
• plastic parts ........ 226
• safety belts ........ 228
• washing ........ 224

Index

• waxing ........ 224
• wheels ........ 225
• wiper blades ........ 227

Climate control (see Air conditioning

• or Heating) ........ 32, 35, 38

Clock adjust

• 6-CD in dash ........ 27

• AM/FM Stereo ........ 19–20

• AM/FM/CD ........ 21

• AM/FM/Tape/CD ........ 24

• Compass, electronic ........ 79, 81

• calibration ........ 81

• set zone adjustment ........ 72, 81

• Console ........ 58

• overhead ........ 54–55

Controls

• power seat ........ 101
• steering column ........ 65

Coolant

• checking and adding ........ 239
• refill capacities ........ 243, 276
• specifications ........ 280, 282

Cruise control

• (see Speed control) ........ 63

• Customer Assistance ........ 193 Ford accessories for your

• vehicle ........ 229 Ford Extended Service

• Plan ........ 217 Getting assistance outside

• the U.S. and Canada ........ 221 Getting roadside assistance ..193 Getting the service you

• need ........ 215 Ordering additional owner’s

• literature ........ 222 The Dispute Settlement

• Board ........ 217

Utilizing the Mediation/

• Arbitration Program ........ 220

D

Daytime running lamps

• (see Lamps) ........ 43

Dipstick automatic transmission

• fluid ........ 256
• engine oil ........ 234

Doors

• lubricant specifications ........ 280

Driveline universal joint and

• slip yoke ........ 259

Driving under special

• conditions ........ 162, 169, 172
• sand ........ 171
• snow and ice ........ 173
• through water ........ 171, 175

E

• Electronic message center ........ 71

Emergencies, roadside

• jump-starting ........ 209

• Emergency Flashers ........ 194

• Emission control system ........ 253

• Engine ........ 282–283

• cleaning ........ 225

• coolant ........ 239

• fail-safe coolant ........ 243

• idle speed control ........ 237 lubrication

• specifications ........ 280, 282

• refill capacities ........ 276

• service points ........ 232–233 starting after a collision ...194

• Engine block heater ........ 153

295

Index

• Engine oil ........ 234
• checking and adding ........ 234
• dipstick ........ 234
• filter, specifications ........ 236, 275
• recommendations ........ 236
• refill capacities ........ 276
• specifications ........ 280, 282
• Exhaust fumes ........ 153

F

• Fail safe cooling ........ 243
• Fluid capacities ........ 276
• Foglamps ........ 43
• Four-Wheel Drive vehicles ........ 164
• driving off road ........ 167
• electronic shift ........ 166
• indicator light ........ 164
• lever operated shift ........ 165 preparing to drive your
• vehicle ........ 156
• Fuel ........ 245 calculating fuel
• economy ........ 74, 249
• cap ........ 247
• capacity ........ 276
• choosing the right fuel ........ 248 comparisons with EPA fuel
• economy estimates ........ 252
• detergent in fuel ........ 249 filling your vehicle
• with fuel ........ 245, 247, 250
• filter, specifications ........ 249, 275 fuel pump shut-off switch ..194 improving fuel economy ...249
• octane rating ........ 248, 282–283
• quality ........ 248
• running out of fuel ........ 249 safety information relating
• to automotive fuels ........ 245 Fuel pump shut-off switch ..194

296

• Fuses ........ 195–196

G

Garage Door Opener (see Homelink wireless

• control system) ........ 67
• Gas cap (see Fuel cap) ........ 247 Gas mileage
• (see Fuel economy) ........ 249
• Gauges ........ 15 GAWR (Gross Axle Weight Rating)
• calculating ........ 179 GVWR (Gross Vehicle Weight Rating)
• calculating ........ 179

H

• Hazard flashers ........ 194
• Head restraints ........ 99, 103
• Headlamps ........ 42
• aiming ........ 44
• autolamp system ........ 42
• bulb specifications ........ 48
• daytime running lights ........ 43
• flash to pass ........ 44
• high beam ........ 43
• replacing bulbs ........ 49
• turning on and off ........ 42 Heating
• heater only system ........ 32 heating and air conditioning
• system ........ 33, 35, 38 Homelink wireless control
• system ........ 67
• Hood ........ 231

I

• Ignitation ........ 149, 282–283

Index

Infant seats

• (see Safety seats) ........ 138 Inspection/maintenance
• (I/M) testing ........ 254 Instrument panel
• cleaning ........ 227
• cluster ........ 10 lighting up panel and
• interior ........ 44

J

• Jack ........ 203
• positioning ........ 203
• storage ........ 203
• Jump-starting your vehicle ........ 209

K

• Keyless entry system ........ 94
• autolock ........ 92
• programming entry code ........ 94
• Keys ........ 97
• positions of the ignition ........ 149

L

Lamps

• autolamp system ........ 42 bulb replacement
• specifications chart ........ 48
• daytime running light ........ 43
• fog lamps ........ 43
• headlamps ........ 42
• headlamps, flash to pass ........ 44
• instrument panel, dimming ........ 44
• interior lamps ........ 46–47
• replacing bulbs ........ 48–52 Lane change indicator
• (see Turn signal) ........ 46
• Lights, warning and indicator ........ 10
• anti-lock brakes (ABS) ........ 154
• Load limits ........ 176
• Loading instructions ........ 179 Locks
• autolock ........ 92
• childproof ........ 85 Lubricant specifications ..280, 282
• Lug nuts ........ 209
• Lumbar support, seats ........ 101

M

• Message center ........ 71
• english/metric button ........ 75
• system check button ........ 75
• warning messages ........ 76
• Mirrors ........ 54, 60 automatic dimming rearview
• mirror ........ 60
• fold away ........ 62
• heated ........ 61 programmable memory ...88, 102
• side view mirrors (power) ........ 61
• signal ........ 62
• Moon roof ........ 66
• Motorcraft parts ........ 249, 275

O

• Octane rating ........ 248
• Oil (see Engine oil) ........ 234

P

• Parking brake ........ 155
• Parts (see Motorcraft parts) ........ 275 Passenger Occupant
• Classification Sensor ........ 106

297

Index

Power distribution box

• (see Fuses) ........ 196
• Power door locks ........ 84
• Power mirrors ........ 61
• Power point ........ 57
• Power steering ........ 155
• fluid, checking and adding ........ 255
• fluid, refill capacity ........ 276
• fluid, specifications ........ 280, 282
• Power Windows ........ 59 Preparing to drive
• your vehicle ........ 156

R

• Radio ........ 18, 20, 23, 26
• Relays ........ 195
• Remote entry system ........ 86
• illuminated entry ........ 90
• locking/unlocking doors ........ 84 replacement/additional
• transmitters ........ 89
• Reverse sensing system ........ 162
• Roadside assistance ........ 193

S

• Safety Belt Maintenance ........ 120 Safety belts (see Safety
• restraints) ........ 104, 108–112, 114
• Safety defects, reporting ........ 223 Safety
• restraints ........ 104, 108–112, 114
• extension assembly ........ 120
• for adults ........ 109–112
• for children ........ 134–135
• lap belt ........ 114

298

Occupant Classification

• Sensor ........ 106
• safety belt maintenance ........ 120
• warning light and chime ........ 116
• Safety seats for children ........ 138 Seat belts (see
• Safety restraints) ........ 104
• Seats ........ 99
• child safety seats ........ 138
• heated ........ 38, 102
• memory seat ........ 88, 102 SecuriLock passive anti-theft
• system ........ 97
• Servicing your vehicle ........ 230 Setting the clock
• AM/FM stereo ........ 19–20
• AM/FM/CD ........ 21
• AM/FM/In-dash 6 CD ........ 27
• AM/FM/Tape/CD ........ 24
• Snowplowing ........ 7, 190–191 Spark plugs,
• specifications ........ 275, 282–283 Special notice
• ambulance conversions ........ 7
• four-wheel drive vehicles ........ 192
• utility-type vehicles ........ 7 Specification chart,
• lubricants ........ 280, 282
• Speed control ........ 63 Starting your
• vehicle ........ 149–150, 153
• jump starting ........ 209 Steering wheel
• controls ........ 65
• tilting ........ 54

T

• Tailgate ........ 81

Index

Temperature control

• (see Climate control) ........ 32
• Tilt steering wheel ........ 54
• Tires ........ 203, 262–263
• alignment ........ 270
• care ........ 268
• changing ........ 203, 205
• checking the pressure ........ 268
• label ........ 268
• replacing ........ 273
• rotating ........ 270
• safety practices ........ 273
• sidewall information ........ 264
• snow tires and chains ........ 274
• spare tire ........ 203
• terminology ........ 263
• tire grades ........ 263
• treadwear ........ 262, 272
• Towing ........ 179
• recreational towing ........ 189
• trailer towing ........ 179
• Traction-lok rear axle ........ 156 Transfer case
• fluid checking ........ 258
• Transmission ........ 156 brake-shift interlock
• (BSI) ........ 156–157 fluid, checking and adding
• (automatic) ........ 256
• fluid, refill capacities ........ 276 lubricant specifications ..280, 282
• Turn signal ........ 46

V

• Vehicle dimensions ........ 283, 287 Vehicle Identification Number
• (VIN) ........ 288
• Vehicle loading ........ 176
• Ventilating your vehicle ........ 153

W

• Warning lights (see Lights) ........ 10
• Washer fluid ........ 234
• Water, Driving through ........ 175 Windows
• power ........ 59
• power down back window ........ 60 Windshield washer fluid and
• wipers ........ 53
• checking and adding fluid ........ 234
• replacing wiper blades ........ 53

299

300

301

302

303

304